| HOME | HELP | FEEDBACK | SUBSCRIPTIONS | ARCHIVE | SEARCH | TABLE OF CONTENTS |
|
|
|
|||||||
|
|||||||||
University of Minnesota, St. Paul 55108
1 Correspondence:
385 Animal Science/Veterinary Medicine Bldg., 1988 Fitch Ave. (phone: 612-625-3743; fax: 612-625-1210; E-mail:
spie0073{at}umn.edu).
A study was conducted to evaluate the nutrient content and variability of distiller’s dried grains with solubles (DDGS) originating from new (less than 5 yr old) ethanol plants in Minnesota and South Dakota. Ten plants (8 MN, 2 SD) participated in the study, submitting a total of 118 samples. Samples were collected every 2 mo from ten ethanol plants in the Minnesota-South Dakota (MNSD) region from 1997 to 1999 and were analyzed for amino acid levels, DM, CP, crude fiber, crude fat, ash, ADF, NDF, Ca, P, K, Mg, S, Na, Zn, Mn, Cu, and Fe analysis. Digestible energy (DE), ME, and NFE levels were also calculated. Means (dry-matter basis) and coefficients of variation for each nutrient among all plants during 1997 to 1999 were DM (88.9%, 1.7%), CP (30.2%, 6.4%), crude fat (10.9%, 7.8%), crude fiber (8.8%, 8.7%), ash (5.8%, 14.7%), NFE (45.5%, 6.1%), ADF (16.2%, 28.4%), NDF (42.1%, 14.3%), calculated DE (3,990 kcal/kg, 3.24%), calculated ME (3,749 kcal/kg, 3.28%), Arg (1.20%, 9.1%), His (0.76%, 7.8%), Ile (1.12%, 8.7%), Leu (3.55%, 6.4%), Lys (0.85%, 17.3%), Met (0.55%, 13.6%), Phe (1.47%, 6.6%), Thr (1.13%, 6.4%), Trp (0.25%, 6.7%), Val (1.50%, 7.2%), Ca (0.06%, 57.2%), and P (0.89%, 11.7%), respectively. Among the amino acids analyzed, Lys was the most variable (CV = 17.3%), followed by Met (CV = 13.6%). Nutrient levels of MNSD DDGS were higher in crude fat, NDF, DE, ME, P, Lys, Met, and Thr and lower for DM, ADF, and Ca than NRC (1998) values. Nutrient values differed between years for ash, DE, Mn, Zn, Cys (P < 0.10), Fat, TDN, ME, Met, Ile (P < 0.05), Ca, P, K, Mg, and Cu (P < 0.01). These results suggest that gross energy; P; and total Lys, Met, and Thr levels are higher in DDGS from MNSD ethanol plants compared to published values and chemical analysis values of a DDGS sample obtained from an older Midwestern plant.
Key Words: Distiller’s Grains • Distiller’s Solubles • Nutrients
This article has been cited by other articles:
|
|
 |
|
  D. J. Schingoethe, K. F. Kalscheur, A. R. Hippen, and A. D. Garcia Invited review: The use of distillers products in dairy cattle diets J Dairy Sci, December 1, 2009; 92(12): 5802 - 5813. [Abstract] [Full Text] [PDF]
|
|
|
|
 |
|
 A. Bandegan, W. Guenter, D. Hoehler, G. H. Crow, and C. M. Nyachoti Standardized ileal amino acid digestibility in wheat distillers dried grains with solubles for broilers Poult. Sci., December 1, 2009; 88(12): 2592 - 2599. [Abstract] [Full Text] [PDF]
|
|
|
|
 |
|
 M. L. May, M. J. Quinn, C. D. Reinhardt, L. Murray, M. L. Gibson, K. K. Karges, and J. S. Drouillard Effects of dry-rolled or steam-flaked corn finishing diets with or without twenty-five percent dried distillers grains on ruminal fermentation and apparent total tract digestion J Anim Sci, November 1, 2009; 87(11): 3630 - 3638. [Abstract] [Full Text] [PDF]
|
|
|
|
|
|
Z. J. Cao, J. L. Anderson, and K. F. Kalscheur Ruminal degradation and intestinal digestibility of dried or wet distillers grains with increasing concentrations of condensed distillers solubles J Anim Sci, September 1, 2009; 87(9): 3013 - 3019. [Abstract] [Full Text] [PDF]
|
|
|
|
|
|
S. J. Winterholler, D. L. Lalman, T. K. Dye, C. P. McMurphy, and C. J. Richards In situ ruminal degradation characteristics of by-product feedstuffs for beef cattle consuming low-quality forage J Anim Sci, September 1, 2009; 87(9): 2996 - 3002. [Abstract] [Full Text] [PDF]
|
|
|
|
|
|
B. E. Depenbusch, C. M. Coleman, J. J. Higgins, and J. S. Drouillard Effects of increasing levels of dried corn distillers grains with solubles on growth performance, carcass characteristics, and meat quality of yearling heifers J Anim Sci, August 1, 2009; 87(8): 2653 - 2663. [Abstract] [Full Text] [PDF]
|
|
|
|
|
|
P. E. Urriola, D. Hoehler, C. Pedersen, H. H. Stein, and G. C. Shurson Amino acid digestibility of distillers dried grains with solubles, produced from sorghum, a sorghum-corn blend, and corn fed to growing pigs J Anim Sci, August 1, 2009; 87(8): 2574 - 2580. [Abstract] [Full Text] [PDF]
|
|
|
|
|
|
I. A. Emiola, F. O. Opapeju, B. A. Slominski, and C. M. Nyachoti Growth performance and nutrient digestibility in pigs fed wheat distillers dried grains with solubles-based diets supplemented with a multicarbohydrase enzyme J Anim Sci, July 1, 2009; 87(7): 2315 - 2322. [Abstract] [Full Text] [PDF]
|
|
|
|
 |
|
 X. Hao, M. B. Benke, D. J. Gibb, A. Stronks, G. Travis, and T. A. McAllister Effects of Dried Distillers' Grains with Solubles (Wheat-Based) in Feedlot Cattle Diets on Feces and Manure Composition J. Environ. Qual., June 23, 2009; 38(4): 1709 - 1718. [Abstract] [Full Text] [PDF]
|
|
|
|
|
|
H. H. Stein and G. C. Shurson BOARD-INVITED REVIEW: The use and application of distillers dried grains with solubles in swine diets J Anim Sci, April 1, 2009; 87(4): 1292 - 1303. [Abstract] [Full Text] [PDF]
|
|
|
|
|
|
A. A. Pahm, C. S. Scherer, J. E. Pettigrew, D. H. Baker, C. M. Parsons, and H. H. Stein Standardized amino acid digestibility in cecectomized roosters and lysine bioavailability in chicks fed distillers dried grains with solubles Poult. Sci., March 1, 2009; 88(3): 571 - 578. [Abstract] [Full Text] [PDF]
|
|
|
|
|
|
S. A. Adedokun, O. Adeola, C. M. Parsons, M. S. Lilburn, and T. J. Applegate Standardized Ileal Amino Acid Digestibility of Plant Feedstuffs in Broiler Chickens and Turkey Poults Using a Nitrogen-Free or Casein Diet Poult. Sci., December 1, 2008; 87(12): 2535 - 2548. [Abstract] [Full Text] [PDF]
|
|
|
|
|
|
V. H. Varel, J. E. Wells, E. D. Berry, M. J. Spiehs, D. N. Miller, C. L. Ferrell, S. D. Shackelford, and M. Koohmaraie Odorant production and persistence of Escherichia coli in manure slurries from cattle fed zero, twenty, forty, or sixty percent wet distillers grains with solubles J Anim Sci, December 1, 2008; 86(12): 3617 - 3627. [Abstract] [Full Text] [PDF]
|
|
|
|
|
|
B. N. Janicek, P. J. Kononoff, A. M. Gehman, and P. H. Doane The Effect of Feeding Dried Distillers Grains Plus Solubles on Milk Production and Excretion of Urinary Purine Derivatives J Dairy Sci, September 1, 2008; 91(9): 3544 - 3553. [Abstract] [Full Text] [PDF]
|
|
|
|
|
|
B. J. Kerr, C. J. Ziemer, T. E. Weber, S. L. Trabue, B. L. Bearson, G. C. Shurson, and M. H. Whitney Comparative sulfur analysis using thermal combustion or inductively coupled plasma methodology and mineral composition of common livestock feedstuffs J Anim Sci, September 1, 2008; 86(9): 2377 - 2384. [Abstract] [Full Text] [PDF]
|
|
|
|
|
|
C. L. Engel, H. H. Patterson, and G. A. Perry Effect of dried corn distillers grains plus solubles compared with soybean hulls, in late gestation heifer diets, on animal and reproductive performance J Anim Sci, July 1, 2008; 86(7): 1697 - 1708. [Abstract] [Full Text] [PDF]
|
|
|
|
|
|
S. K. Linneen, J. M. DeRouchey, S. S. Dritz, R. D. Goodband, M. D. Tokach, and J. L. Nelssen Effects of dried distillers grains with solubles on growing and finishing pig performance in a commercial environment J Anim Sci, July 1, 2008; 86(7): 1579 - 1587. [Abstract] [Full Text] [PDF]
|
|
|
|
|
|
M. E. Jacob, J. T. Fox, S. K. Narayanan, J. S. Drouillard, D. G. Renter, and T. G. Nagaraja Effects of feeding wet corn distillers grains with solubles with or without monensin and tylosin on the prevalence and antimicrobial susceptibilities of fecal foodborne pathogenic and commensal bacteria in feedlot cattle J Anim Sci, May 1, 2008; 86(5): 1182 - 1190. [Abstract] [Full Text] [PDF]
|
|
|
|
|
|
E. J. Kim, C. M. Amezcua, P. L. Utterback, and C. M. Parsons Phosphorus Bioavailability, True Metabolizable Energy, and Amino Acid Digestibilities of High Protein Corn Distillers Dried Grains and Dehydrated Corn Germ Poult. Sci., April 1, 2008; 87(4): 700 - 705. [Abstract] [Full Text] [PDF]
|
|
|
|
 |
|
 M. E. Jacob, J. T. Fox, J. S. Drouillard, D. G. Renter, and T. G. Nagaraja Effects of Dried Distillers' Grain on Fecal Prevalence and Growth of Escherichia coli O157 in Batch Culture Fermentations from Cattle Appl. Envir. Microbiol., January 1, 2008; 74(1): 38 - 43. [Abstract] [Full Text] [PDF]
|
|
|
|
|
|
C. Martinez-Amezcua, C. M. Parsons, V. Singh, R. Srinivasan, and G. S. Murthy Nutritional Characteristics of Corn Distillers Dried Grains with Solubles as Affected by the Amounts of Grains Versus Solubles and Different Processing Techniques Poult. Sci., December 1, 2007; 86(12): 2624 - 2630. [Abstract] [Full Text] [PDF]
|
|
|
|
|
|
D. H. Kleinschmit, J. L. Anderson, D. J. Schingoethe, K. F. Kalscheur, and A. R. Hippen Ruminal and Intestinal Degradability of Distillers Grains plus Solubles Varies by Source J Dairy Sci, June 1, 2007; 90(6): 2909 - 2918. [Abstract] [Full Text] [PDF]
|
|
|
|
|
|
C. Pedersen, M. G. Boersma, and H. H. Stein Digestibility of energy and phosphorus in ten samples of distillers dried grains with solubles fed to growing pigs J Anim Sci, May 1, 2007; 85(5): 1168 - 1176. [Abstract] [Full Text] [PDF]
|
|
|
|
|
|
D. H. Kleinschmit, D. J. Schingoethe, K. F. Kalscheur, and A. R. Hippen Evaluation of Various Sources of Corn Dried Distillers Grains Plus Solubles for Lactating Dairy Cattle J Dairy Sci, December 1, 2006; 89(12): 4784 - 4794. [Abstract] [Full Text] [PDF]
|
|
|
|
|
|
M. H. Whitney, G. C. Shurson, L. J. Johnston, D. M. Wulf, and B. C. Shanks Growth performance and carcass characteristics of grower-finisher pigs fed high-quality corn distillers dried grain with solubles originating from a modern Midwestern ethanol plant J Anim Sci, December 1, 2006; 84(12): 3356 - 3363. [Abstract] [Full Text] [PDF]
|
|
|
|
|
|
J. J. Reed, G. P. Lardy, M. L. Bauer, M. Gibson, and J. S. Caton Effects of season and inclusion of corn distillers dried grains with solubles in creep feed on intake, microbial protein synthesis and efficiency, ruminal fermentation, digestion, and performance of nursing calves grazing native range in southeastern North Dakota J Anim Sci, August 1, 2006; 84(8): 2200 - 2212. [Abstract] [Full Text] [PDF]
|
|
|
|
|
|
L. P. F. Carvalho, A. R. J. Cabrita, R. J. Dewhurst, T. E. J. Vicente, Z. M. C. Lopes, and A. J. M. Fonseca Evaluation of palm kernel meal and corn distillers grains in corn silage-based diets for lactating dairy cows. J Dairy Sci, July 1, 2006; 89(7): 2705 - 2715. [Abstract] [Full Text] [PDF]
|
|
|
|
|
|
M. H. Whitney, G. C. Shurson, and R. C. Guedes Effect of dietary inclusion of distillers dried grains with solubles on the ability of growing pigs to resist a Lawsonia intracellularis challenge J Anim Sci, July 1, 2006; 84(7): 1860 - 1869. [Abstract] [Full Text] [PDF]
|
|
|
|
|
|
T. C. Gilbery, G. P. Lardy, S. A. Soto-Navarro, M. L. Bauer, and J. S. Caton Effects of corn condensed distillers solubles supplementation on ruminal fermentation, digestion, and in situ disappearance in steers consuming low-quality hay J Anim Sci, June 1, 2006; 84(6): 1468 - 1480. [Abstract] [Full Text] [PDF]
|
|
|
|
|
|
H. H. Stein, M. L. Gibson, C. Pedersen, and M. G. Boersma Amino acid and energy digestibility in ten samples of distillers dried grain with solubles fed to growing pigs J Anim Sci, April 1, 2006; 84(4): 853 - 860. [Abstract] [Full Text] [PDF]
|
|
|
|
|
|
C. Leonardi, S. Bertics, and L. E. Armentano Effect of Increasing Oil from Distillers Grains or Corn Oil on Lactation Performance J Dairy Sci, August 1, 2005; 88(8): 2820 - 2827. [Abstract] [Full Text] [PDF]
|
|
|
|
|
|
C. Pedersen, H. Jonsson, J. E. Lindberg, and S. Roos Microbiological Characterization of Wet Wheat Distillers' Grain, with Focus on Isolation of Lactobacilli with Potential as Probiotics Appl. Envir. Microbiol., March 1, 2004; 70(3): 1522 - 1527. [Abstract] [Full Text] [PDF]
|
|
| HOME | HELP | FEEDBACK | SUBSCRIPTIONS | ARCHIVE | SEARCH | TABLE OF CONTENTS |
